Monroe Shocks and Struts, Air Suspension Parts and Air Ride Suspension Conversion Kits

Well, the main and most common symptoms of a leaking or failed air suspension a sagging rear end. Other major clues are that your air compressor isn't working or is running way too often. Another pretty common tip off of a problem air suspension is your Expedition's inability to reach or maintain recommended height.

Not Good!  See how low this vehicle is riding?

Failure to repair your Ford Expedition suspension system can also lead to some major safety issues, such as an air spring blowing while doing 75MPH could send the car into a spin. Really, really not good.






A faulty air suspension can cause loss of work, car rental, towing bills, excessive repair costs (especially by big car dealerships) and in general can be very frustrating and inconvenient to say the least. Bottom line:  it can cost you big bucks.

"Why Did My Expedition Air Suspension Fail?..."

The Ford Expedition air suspension systems are subject to a lot of troubles, but it's greatest enemy is time. The air spring is made with rubber parts that dry-rot in 5 to 7 years. The Expedition air suspension's longevity is determined by how much extreme heat and cold your Expedition is subjected. These weather conditions will quickly degrade the parts of an air suspension system. A lot of times the electronic devices begin to fail with age, which just intensifies the problems related to the Ford Expedition air suspension.

Notice the cracks in the air bag?

As time goes by, the Expedition suspension is subject to extreme wear and the sagging poor shocks and spring quality will make it difficult to properly align. This causes excessive wear to the all four tires and eventually ruins the great ride you deserve as a Ford Expedition owner. So not only do you have a lousy ride, but now you get the pleasure of having to buy tires more frequently.

"Wait! There's Good News..."

You can avoid these high costs and the frustration by installing the Strutmasters Ultimate Ride Conversion Suspension System developed specifically for your Expedition. Our suspension solution replaces your Expedition air suspension with the highest quality, lifetime non-air suspension system. All of the components in this conversion kit were designed and manufactured in the United States and are made of the very highest quality material.

When installed, you will not only be safe once again, but you will have that new ride feel as we put our Total Ride Satisfaction Promise on our air to non-air conversion kits. We know that you will love the ride in your Expedition suspension and you're gonna love the dependability of this conversion kit.




We offer a Lifetime Warranty on our air to non-air conversion kits. With our Strutmasters Warranty, we will even replace any of our suspension parts free of charge for any damage over the life of the vehicle.

No one else offers this level of service and quality. We have over 260,000 happy customers who have been using our suspension system every day for over 10 years. We get tons of letters and e-mails every month thanking us for making this exclusive 4 Wheel Air Suspension Conversion Kit available for your Ford Expedition.

People tell us how great it is to have that new car ride back again and know that they can get many more years of use from their Expedition and have the confidence of being safe on the road. Do what thousands of others in your shoes have done and Beat The Air Ride System by ordering your Strutmasters Ultimate Ride Conversion Suspension Kit today.

Take a look at what our satisfied and happy customers have to say about the Ford Expedition Strutmasters Conversion Kit: Scroll down to see what some of our customers have had to say.

"What The Dealer Won't Tell You..."

With the insider information I know today, I can assure you that the OEM parts will always fail and are just another way for car dealers to "line their pockets" at your expense.

"Dealerships Have Used This Dirty Little Trick For Years..."

The dealerships and parts dealers want you to buy replacement parts because they know that your other air suspension and electronic parts are bound to fail in the very near future, forcing you to continue to buy more and more air suspension replacement parts over time. They make a killing as you grow more and more frustrated!

The stark reality is that luxury car & SUV owners like you, have been left in the dark. These replacement parts are expensive and in most cases it will be necessary for you to pay a dealership a bundle of cash to install them. Increasing even more the cost to get your ride fixed. Many times, you will also have to rent a car because the dealership will take days to get your air suspension working properly.

The worst part about this whole situation is that you don't have a car, the dealership takes forever to fix your ride and then the dealership will use that against you and magically find lots of other parts that “have” to be fixed. You know because it's happened to you before or to someone you know.

Don't fall for their trap...it's not pretty once they have you. They will be laughing all the way to the bank. Please, don't let these guys take your hard earned money. You have another option, and Strutmasters had done all the hard work for you.

"Some Great Reasons To Act Now" LOW PRICE GUARANTEE MADE IN THE USA QUICK & EASY INSTALLATION FRUSTRATION ELIMINATED FOREVER!

Your satisfaction is our priority!

Upon your order, we can even provide you with one of our approved installers that are local to you and have agreed not charge more than 1 hour per wheel for labor. This is one of our easiest installs and has been done by many "Do It Your Selfers". If you can do brakes, you can do this...No Sweat!

Our suspension kits are always in stock and will usually ship the same day that you place your order. You will receive a confirmation email with delivery tracking to your door.

Chip "The Strut Man" Lofton

Select The Smart Suspension Solution For Your Ford Expedition  YES! Chip, I can't wait to get that new car ride again. I want to order your 2003-2006 Ford Expedition 4 Wheel Air Suspension Conversion Kit. Click the "Add To Cart" button below... Special Price: $639.00

1. Two Front Coil-Over-Struts Engineered For Your 2003-2006 Ford Expedition

2. Two Rear Coil-Over-Struts Engineered For Your 2003-2006 Ford Expedition

3. Detailed Installation Instructions

4. Instructions To Disable The Service Air Suspension Dash Light

1. Does the kit include instructions?

Answer:  All of Strutmasters Conversion Kits include installation instructions.


2. How do I get the air out of the Air springs?

Answer:  A knife works just fine or you can remove the air spring solenoid to evacuate the air from the air springs.


3. If I have a 4 wheel drive Expedition or Navigator (97-02) do I have to convert the front?

Answer:  It is possible to convert the rear and not the front, however, it is not recommended unless you have a functioning compressor. A full conversion is recommended on a 4 wheel air suspension vehicle with a failed compressor.


4. If I have an 03-05 Expedition or Navigator do I have to convert all 4 wheels?

Answer:  Yes. If you attempt to try a 2 wheel kit conversion on the 03-05 Models, the end you try to leave with the air suspension will collapse forcing you to convert the remaining end.


5. How do you orient the rear air springs?

Answer:  Each kit comes assembled in the manner it installs into the vehicle. A general rule of thumb is that if you can read the Strutmasters name on the side of the spring right-side up, then they are installed correctly.


6. How long should an install take?

Answer:  Generally speaking, install times should be around an hour per wheel, when professionally installed.


7. Do I need any special tools to install the conversion kit?

Answer:  Certainly not. A good set of metric sockets and a couple of jacks and jack stands are all you need.


8. Do I have to compress the springs to install the rear kit?

Answer:  No. If you follow our step by step instructions you do not have to compress the rear springs to install them.


9. How do I disconnect the airline from the dryer?

Answer:  You press and hold down the plastic orange ring while simultaneously pulling the airline from the dryer.


10. How do I disconnect the airline from the solenoids?

Answer:  You press and hold down the plastic orange ring while simultaneously pulling the airline from the solenoid.
1. How will my car ride with a conversion kit installed?

Answer:  The kits are designed to give you a dependable, smooth ride, at factory recommended ride height.  Many customers say the kits actually improve the handling and cornering on their vehicles.  We have more than 250,000 conversion kits on the road and our customers love them.


2. Can I tow a trailer?

Answer:  A vehicle converted with a Strutmasters conversion kit will tow the same capacity as it did with the original suspension.


3. How hard is it to install?

Answer:  Our thousands of authorized repair shops have told us this:  "If you can do a brake job, you can install a Strutmasters conversion kit."  They also tell us the conversion kits are easier to install than most of the original air suspension parts.  Most shops will charge about 1 hour per wheel.


4. What modifications will I have to make to the vehicle?

Answer:  Our conversion kits are designed to bolt right onto your vehicle with no welding, cutting or modifications.  Simply remove the old air suspension parts and bolt on the conversion kit.


5. How do I get the warning light off?

Answer:  Our conversion kits come with detailed instructions for installation � and almost all of our kits include steps on how to bypass any electronics and suspension warning lights.


6. How long will the conversion kit last?

Answer:  All Strutmasters conversion kits come with a lifetime warranty.  They are designed to last for the life of your vehicle.  Our conversion kits eliminate your air suspension problems forever!


7. What makes you better than the competition?

Answer:  Some of our competitors use inferior Chinese steel and other Chinese parts.  Customers and shops have spoken and prefer the quality and durability of our parts, which are made and assembled in the United States.
Some of our competitors use coil springs �off the shelf� and modify them for a particular vehicle.  Reheating a steel coil spring is very bad news because it makes the spring brittle and leads to failure.


8. What if I don�t have the money to convert the entire vehicle?

Answer:  Strutmasters understands that you work hard for your money.  Our owner, Chip Lofton, knows that vehicles seem to pick the worst possible time to need repair � his car failed while on vacation.  Therefore, Strutmasters offers two-wheel conversion kits on as many vehicles as possible.  We also offer a special savings for customers who convert all four wheels.


9. Why should I convert my suspension if I do not plan to keep the car?

Answer:  A Strutmasters conversion kit may help you fall in love with your vehicle all over again!  If not, a conversion kit will pay off when you decide to sell it.  A vehicle with a good ride sells for more money and you will not be hearing back from the new owner complaining that you sold them a lemon.

1. How long will it take for my product to get here?

 

2. How much will shipping cost?

 

3. What is the standard form of delivery?

 

4. What shipping options do you offer?

 

5. I ordered my package over the weekend.  Why hasn’t it gotten to me yet?

 

6. Does it take longer to ship online orders than it does if I call in?

 

7. Are shipping fees refundable if I return my product?

 

8. Why wasn’t I offered some of the shipping options that are available?

 

9. Can I have my order shipped to a different address or more than one address?

 

10. What type of shipping do you use for Free Shipping when it is available?

 

11. How long will it take for my order to ship out once the order is placed?

 

12. What is your return policy?

2) Used or installed product cannot be returned except for warranty claims.

3) A 20% restocking fee will apply to all non-warranty returns.

4) Customer is responsible for both the original shipping and return freight costs.

5) Custom-made or fabricated products cannot be returned.

6) Altered parts cannot be returned.

7) Items to be returned must be returned within 30 days of the purchase invoice date.

8) We reserve the right to refuse any product for return.